2019 Ford Transit

2020-2023 Transit vehicles with the 10R80 automatic transmission exhibit harsh or delayed engagement and rough gear changes, similar to the issue found across Ford's 10-speed lineup. Commercial use with frequent stop-start driving exacerbates the harshness.

Ford issued a TSB for Transit vehicles with the 10R80 addressing PCM software calibration and internal valve body issues. The dealer will reflash the PCM and, if necessary, replace the valve body or solenoid pack. Use only Mercon ULV transmission fluid.

A software error can cause the HVAC system controls to become completely inoperative, including the defogging and defrosting functions. This is a safety issue in cold or wet weather when windshield visibility is compromised. Ford recalled approximately 31,339 vehicles.

Ford issued a recall for 2022-2023 Transit vehicles to update the HVAC control module software. Contact your dealer to check your VIN. The repair is free of charge.

The instrument panel cluster may not properly illuminate warning lights or display gauges, leaving the driver without speedometer, fuel gauge, temperature gauge, and critical warning indicators. This is a significant safety risk especially for commercial fleet vehicles.

Ford issued a recall to reprogram or replace the instrument panel cluster. Contact your dealer to verify your VIN. The repair is free of charge. Do not drive the vehicle if the cluster is completely dark.

Some 2020-2022 Transit vehicles built on or before April 26, 2022 may lose power steering assist at initial vehicle startup. The steering becomes very heavy and difficult to turn, posing a safety risk when pulling away from a parking spot into traffic.

Ford issued a TSB to update the power steering control module software. Restarting the engine may temporarily restore steering assist. Contact your dealer for the permanent software update.

2022 Transit vehicles built on or before March 28, 2022 that are not equipped with a telematics control unit (TCU) may experience a no crank/no start condition due to a discharged battery. Fleet vehicles that sit for extended periods are especially susceptible.

Ford issued a TSB to install a software update that corrects the parasitic battery drain. The dealer will also test and replace the 12V battery if it has been damaged by repeated deep discharges. Consider installing a battery maintainer for fleet vehicles that sit idle.

Rollx Vans (Rollx) is recalling certain GMC Yukon, Sierra, Chevrolet Express 2500, Ford Transit, E-250, Toyota Sienna, Sienna Hybrid, Honda Odyssey, Chrysler Town and Country, Voyager, Pacifica, Dodge Grand Caravan, and Ram Promaster vehicles equipped with QRT-Deluxe and QRT-Max wheelchair restraints. Please refer to Rollx's recall report for specific model year information. The retractors may not lock, preventing the wheelchair from being properly secured.

An unsecured wheelchair can move during transit, increasing the risk of injury.

Rollx will work with Q'Straint to inspect and replace the retractors as necessary, free of charge. Owner notification letters were mailed February 5, 2026. Owners may contact Rollx's customer service at 1-800-956-6668.

Ford Motor Company (Ford) is recalling certain 2015-2019 Lincoln MKC, Mustang, F-350 SD, F-250 SD, F-450 SD, 2015-2017 Lincoln Navigator, Expedition, 2015-2018 Edge, Transit Connect, 2016-2019 F-550 SD, Transit, 2017-2019 Econoline, and 2019 Ranger vehicles. The rearview camera may display a distorted, inverted, or blank image when the vehicle is in reverse.

A rearview camera that displays an inverted, distorted, or blank image can reduce the driver’s view behind the vehicle, increasing the risk of a crash.

Dealers will inspect and replace the rearview camera as necessary, free of charge. Owner notification letters were mailed January 13, 2026. Ford owners will receive letters in phases, beginning January 2026 and May 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S89. This recall expands previous NHTSA recall number 25V270. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning September 8, 2025.

Ford Motor Company (Ford) is recalling certain 2015-2020 Transit vehicles. An incorrect driveshaft torsional damper service kit may have been installed, which can allow the damper shield to contact the parking brake cable, possibly resulting in parking brake failure.

Parking brake failure can result in unintended vehicle movement, increasing the risk of a crash.

Dealers will replace the passenger side parking brake cable with a cable that provides sufficient clearance to the damper shield, free of charge. Interim owner notification letters were mailed on September 24, 2021. Owner notification letters were mailed on March 14, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S39.

Ford Motor Company (Ford) is recalling certain 2019 Transit T150, T250, T350 vehicles equipped with aluminum alloy wheels. The wheel mounting surface of the axle flange may be warped and cause the wheel studs to fracture.

Fractured studs may allow the wheel to detach, increasing the risk of crash.

Dealers will inspect and if necessary, replace the rear axle shaft assembly, axle shaft mounting bolts, and rear wheel lug nuts, free of charge. Owner notification letters were mailed on June 28, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S21.

National Van Builders, Inc. (National Van Builders) is recalling certain vehicles based on 2019-2020 Ford Transit and 2019 Ram Promaster vans equipped with Freedman GO-ES foldaway seats. The seat belt retractor block out zone may have not been set correctly, potentially resulting in a seat belt that may not properly secure the occupant. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 209, "Seat Belt Assemblies."

An unsecured occupant has an increased risk of injury in the event of a crash.

National Van Builders will notify owners, and dealers will replace the retractors, free of charge. The recall began May 19, 2020. Owners may contact Freedman customer service at 1-800-443-4540 or National Van Builders customer service at 1-800-527-7477.

TransitWorks is recalling certain Driverge vehicles based on 2019-2020 Ford Transit vans equipped with Freedman Seating Company (FSC) PT Foldaway and GO-ES 3-point Foldaway seats. The seat belt retractor block out zone may have not been set correctly, potentially resulting in a seat belt that may not properly secure the occupant. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 209, "Seat Belt Assemblies."

An unsecured occupant has an increased risk of injury in the event of a crash.

TransitWorks will notify owners, and dealers will replace the retractors, free of charge. The recall began May 13, 2020. Dealers can contact Freedman Seating Company for parts and reimbursement information at 1-800-443-4540.

LA West Inc. (LA West) is recalling certain 2018-2019 Ford Transit vehicles modified to be equipped with glass roof hatches. Temperature and vibration stresses may cause the tempered glass roof hatch to shatter.

If the tempered glass roof hatch shatters, glass fragments may fall onto passengers, increasing the risk of an injury.

LA West will notify owners, and dealers will replace the hatch lids, free of charge. The recall began July 11, 2019. Owners may contact LA West customer service at 1-704-498-4940.

TransitWorks is recalling certain 2015-2018 Ford Transit, 2018 Ford Transit Connect, and 2016 Dodge Ram ProMaster vehicles modified to be equipped with Freedman Seating GO-ES seats. When the back seat cushion is rotated from the stowed position to the upright position, the seat cushion may not remain locked into place when under load, such as in a crash or a sudden stop.

In the event of a crash, if the seat back moves, the seat occupant has an increased risk of injury.

TransitWorks has notified owners and instructed them to contact Freedman seats for a repair kit. The recall began December 19, 2019. Owners may contact Freedman Seating customer service at 1-800-443-4540 or TransitWorks customer service at 1-855-337-9543.

XL Hybrids, Inc (XL) is recalling certain 2015-2018 Ford Transit vehicles modified to be equipped with XL's electric hybrid system. The cardan (universal) joint on the front driveshaft may fail, possibly causing the front driveshaft to detach.

If the front driveshaft detaches from the vehicle, drive power will be lost, increasing the risk of a crash. The detached driveshaft may also create a road hazard, increasing the risk of a crash for following traffic.

XL will notify owners, and dealers will replace the front driveshaft with an updated one, free of charge. The recall began April 15, 2019. Owners may contact XL Hybrid's customer service at 1-833-953-5338.