2012 Volkswagen Beetle

The 2.0T EA888 engine timing chain tensioner fails, allowing the chain to develop slack and rattle on cold starts. If the tensioner fails completely, the chain can skip teeth, causing catastrophic valve-to-piston contact.

Replace the timing chain, tensioner, and guides with the updated revision parts. VW has updated the tensioner design multiple times. Early detection via cold-start rattle allows for a preventive repair before engine damage occurs.

The factory diverter valve diaphragm tears, causing boost leaks. Symptoms include power loss, a fluttering or whooshing sound during boost, and rough idle. The condition often worsens in hot weather.

Replace with an updated OEM diverter valve or a piston-style aftermarket unit that eliminates the failure-prone rubber diaphragm. The repair takes about 15 minutes and requires minimal tools.

The power window regulators fail frequently, causing windows to drop into the door, move slowly, or make grinding noises. The Beetle's unique curved glass design puts additional stress on the regulator cables and guides.

Replace the window regulator assembly. The repair involves removing the door panel and unbolting the glass from the regulator. OEM and aftermarket regulators are available. Some owners replace the motor separately if only the motor has failed.

The convertible top hydraulic system develops leaks and the top motor can fail, causing the top to operate slowly or stop midway. Fluid leaks into the trunk area and can damage electronics and carpet.

Replace the hydraulic cylinders, lines, or top motor as diagnosed. Flush and refill the hydraulic system. Check for and repair any fluid damage to trunk-area components.

The DQ200 7-speed dry DSG (1.8T) or DQ250 6-speed wet DSG (2.0T) develops mechatronic unit failures causing harsh shifting, gear selection errors, and loss of drive. Warning lights for the transmission illuminate.

Replace or repair the DSG mechatronic unit. Software updates may address minor shift quality issues. Regular DSG fluid changes are essential — every 40,000 miles for wet DSG, and the dry DSG also benefits from periodic service.

Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2012-2014 Volkswagen Beetle and Beetle Convertible vehicles. The driver's side air bag inflator may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.

An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.

Volkswagen will notify owners, and dealers will replace the driver frontal air bag, free of charge. The recall began March 19, 2021. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 69BC.

Tenneco Automotive (Tenneco) is recalling certain Beck/Arnley Master Cylinders, part number 072-9831, sold as aftermarket or replacement parts for 2004-2018 Volkswagen Jetta, and 2012-2019 Volkswagen Beetle vehicles. The fluid seal crimp on the master cylinder may be insufficient, causing brake fluid to leak or the cylinder to come apart.

If there is a brake fluid leak, it can reduce braking ability, increasing the risk of a crash.

Beck/Arnley will notify the distributors that sold the master cylinders and will work with the distributors to notify the end users. Affected master cylinders will be exchanged for a new master cylinder (part number 072-9990), free of charge. The recall began October 30, 2020. Owners may contact Tenneco customer service at 1-800-625-9319.

Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2017 Volkswagen Passat, 2018 Tiguan LWB, 2007-2009 Jetta Sedan, 2011-2013, 2015 and 2019 Jetta, 2013 Jetta Hybrid, 2008-2009 Jetta Sportwagen, 2015 Golf Sportwagen, 2013 Golf, 2008-2010 and 2012-2013 Beetle and Beetle Convertible, 2008-2010 Beetle, and Beetle Convertible vehicles. Modifications made while the vehicles were in an internal evaluation period may cause the affected vehicles to not comply with all of the applicable regulatory requirements.

If the vehicles do not meet all regulatory requirements, there could be an increased risk of a crash, fire, or injury.

Volkswagen will notify owners and repurchase the affected vehicles. The recall began November 6, 2019. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 01D7. Note: This recall is an expansion of NHTSA recall number 18V-329.

Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2015-2019 GTI, 2015-2016 and 2018-2019 Golf, 2012-2019 Beetle and Beetle Convertible, 2017-2019 Golf SportWagen and 2011-2018 Jetta vehicles equipped with an automatic transmission, manual handbrake and keyless entry. A build-up of silicate on the shift lever micro switch contacts may enable the key to be removed from the ignition when the transmission shift lever is not in "Park."

Removing the key while the shift lever is in a position other than "Park" increases the risk of an unintended vehicle rollaway that may result in personal injury or a crash.

Volkswagen will notify owners, and dealers will install an additional switch and circuit board, free of charge. The recall began November 19, 2019. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 37M2.

Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2011-2013 Jetta vehicles manufactured March 1, 2010, to November 30, 2012, and 2012-2013 Beetle vehicles manufactured March 1, 2011, to July 31, 2013. The durability of the rear trailing arms may be reduced in vehicles whose rear trailing arms have been previously deformed, such as a result of a rear or side-rear impact crash.

The reduced durability of the trailing arm may result in its sudden fracture, possibly causing loss of vehicle control and increasing the risk of a crash.

Volkswagen will notify owners, and dealers will install a sheet metal inlay on the rear axle trailing arms designed to prevent a sudden loss of control in the event of trailing arm sudden fracture, free of charge. The recall began April 7, 2015. Owners may contact Volkswagen customer service at 1-800-893-5298.

Volkswagen is recalling certain model year 2012-2013 Beetle vehicles, manufactured from February 2012, through August 2012, and equipped with leather sport seats. If the right front passenger seat gets wet, the occupant control module may not properly detect the presence of a child restraint installed in the seat.

If the control module does not detect a child seat installed, the airbag will not turn off. If the airbag does not turn off, in the event of a crash necessitating front airbag deployment, a child secured in the child seat may be at an increased risk for serious injury.

Volkswagen will notify owners, and replace the control modules, free of charge. The recall is expected to begin during January 2013. Owners may contact Volkswagen at 1-800-822-8987.

VOLKSWAGEN IS RECALLING CERTAIN MODEL YEAR 2012 BEETLE VEHICLES. SOME VEHICLES MAY BE EQUIPPED WITH SUMMER TIRES THAT FAIL TO COMPLY WITH FEDERAL MOTOR VEHICLE SAFETY STANDARDS 110 "TIRE SELECTION AND RIMS" AND 139 "NEW PNEUMATIC TIRES FOR LIGHT VEHICLES."

DUE TO AN ERROR AT THE FACTORY, THE AFFECTED VEHICLES WERE PRODUCED WITH SUMMER TIRES THAT ARE POSSIBLY NOT IN COMPLIANCE WITH FEDERAL MOTOR VEHICLE SAFETY STANDARDS 110 "TIRE SELECTION & RIMS" AND 139 "NEW PNEUMATIC TIRES FOR LIGHT VEHICLES." IN ADDITION, CUSTOMERS MAY BE UNAWARE THAT THEIR VEHICLE IS EQUIPPED WITH SUMMER PERFORMANCE TIRES. SUMMER TIRES HAVE DIFFERENT GRIP AND PERFORMANCE CHARACTERISTICS. THESE ISSUES MAY LEAD TO AN INCREASED RISK OF A CRASH.

VOLKSWAGEN WILL NOTIFY OWNERS, AND REPLACE THE NONCOMPLIANT TIRES, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON SEPTEMBER 12, 2012. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-822-8987.