2014 Chevrolet Express

The 2022-2023 Express vans equipped with the 4.3L V6/8-speed automatic or 2.8L turbodiesel/8-speed automatic combinations have defective transmission control module (TCM) software. The software error can cause harsh shifting, sudden deceleration, and the vehicle moving in an unintended direction from a stop. GM received 18 harsh shifting complaints and 5 sudden deceleration reports.

GM recall affecting 54,722 Express units. Dealers reprogram the TCM with updated software that corrects the shift logic. The repair is performed free of charge.

The transmission control valve can fail, causing a brief lockup of the rear wheels or a sudden change in vehicle direction at low speed. This is related to the TCM software issue but involves physical wear in the transmission control valve body. The condition is most likely to occur during low-speed maneuvers.

GM safety recall for TCM software update and, if wear is detected, transmission control valve body replacement. Dealers install updated software that monitors valve performance and detects excessive wear before lockup can occur.

Express vans equipped with the 6.6L gas V8 engine may have a wiring harness susceptible to short circuits. If a short occurs, drivers may receive a low battery voltage warning, the battery may die, or in worst cases, a fire can start in the engine compartment. This is a serious safety concern, especially for fleet and commercial operators.

GM recall for inspection and replacement of the affected wiring harness section. Dealers install protective conduit over the vulnerable wiring to prevent chafing and short circuits. Free of charge under recall.

The Express is based on a platform dating back to 1996, and the 2022 model retains many legacy components. Owners report issues with door hinge and latch mechanisms, rust in the rear cargo area and undercarriage, power window regulator failures, and cooling system leaks from the water pump and radiator. ABS module failures are also common.

Replace door hinges and latches as they wear. Apply rust prevention treatment to the undercarriage. Replace the water pump and radiator hoses as preventive maintenance. ABS module repair or replacement for brake warning light issues.

Owners report check engine lights related to the evaporative emissions (EVAP) system, including faulty purge valves and gas cap seal failures. The fuel level sensor can also malfunction, causing inaccurate fuel gauge readings. On diesel-equipped models, the diesel exhaust fluid (DEF) system can trigger derate conditions.

Replace the EVAP purge valve and gas cap. Replace the fuel level sending unit for inaccurate gauge readings. For diesel models, DEF injector and tank heater replacement may be needed. Clear and relearn the ECM fuel trims after repairs.

General Motors LLC (GM) is recalling certain 2014-2017 Chevrolet Express and GMC Savana vehicles equipped with power windows. Liquid may leak into the driver's power window switch and cause corrosion, resulting in high electrical resistance.

High electrical resistance can increase the risk of a fire.

GM will notify owners, and dealers will replace the driver side window switch, free of charge. The recall began August 10, 2018. Owners may contact Chevrolet customer service at 1-800-222-1020 or GMC customer service at 1-800-462-8782. GM's number for this recall is 18155.

General Motors LLC (GM) is recalling certain 2009-2014 Chevrolet Silverado HD and GMC Sierra HD, 2009 GMC Topkick 5000, 6000, 7000 and 8000 Series and Isuzu F Series, and 2009-2018 Chevrolet Express, and GMC Savana vehicles, equipped with certain Plastic-Handle Fire Extinguishers or Push Button 'Pindicator' Fire Extinguishers. These extinguishers may become clogged, preventing the extinguisher from discharging as expected or requiring excessive force to activate the extinguisher. Additionally, in certain models, the nozzle may detach from the valve assembly with enough force that it could cause injury and also render the product inoperable. For a full list of the affected fire extinguisher models visit: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17E062-5427.pdf

In the event of a fire, if the fire extinguisher does not function properly, it can increase the risk of injury.

GM will notify owners, instructing them to contact Kidde to get a replacement fire extinguisher, free of charge. The recall began June 11, 2018. Owners may contact Chevrolet customer service at 1-800-222-1020, GMC customer service at 1-800-462-8782, and Isuzu customer service at 1-866-441-9638. GM's number for this recall is 18146.

General Motors LLC (GM) is recalling certain model year 2014-2016 Chevrolet Express and GMC Savana incomplete vehicles equipped with a 159 inch wheel base manufactured August 2, 2013, to January 30, 2016. The affected vehicles were shipped to final stage manufacturers without a tire pressure monitoring system (TPMS). As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 138, "Tire Pressure Monitoring Systems."

Without a TPMS, the driver would not be alerted if one or more tires became under inflated. Driving with under inflated tires increases the risk of a crash.

GM will notify owners, and dealers will install the hardware and software necessary to equip the vehicles with a TPMS, free of charge. The recall began on May 25, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 15819.

General Motors (GM) is recalling certain model year 2013-2014 Chevrolet Silverado HD, Chevrolet Express, and GMC Sierra HD vehicles, and model year 2013 GMC Savana compressed natural gas (CNG) vehicles that fail to comply with Federal Motor Vehicle Safety Standard No. 303 "Fuel System Integrity of Compressed Natural Gas Vehicles." In the affected vehicles, the text of the CNG fuel-only label is smaller than the required size, and as a result, may be less noticeable.

Text that does not conform to the required labeling size could inhibit fuel tank inspection practices and safe refueling, increasing the risk of a fire.

GM will notify owners and will send them a replacement label, free of charge. The recall began December 3, 2015. Owners may contact Chevrolet customer service at 1-800-222-1020 or GMC customer service at 1-800-462-8782. GM's number for this recall is 13365.

General Motors LLC (GM) is recalling certain model year 2013-2014 Cadillac CTS, Escalade, Escalade ESV, Chevrolet Suburban, Tahoe, GMC Yukon, and Yukon XL, and 2014 Buick Enclave, Chevrolet Express, Impala, Silverado HD, Traverse, GMC Acadia, Savana, and Sierra HD vehicles. In the affected vehicles, the chassis electronic module may be internally contaminated, resulting in an electrical short.

If the module experiences an electrical short, the vehicle could stall, increasing the risk of a crash.

GM will notify owners, and dealers will replace the chassis electronic module, free of charge. The recall began on December 26, 2014. Owners may contact GM customer service at 1-800-521-7300 (Buick), 1-800-458-006 (Cadillac), 1-800-222-1020 (Chevrolet), and 1-800-462-8782 (GMC). GM’s number for this recall is 14515.

General Motors LLC (GM) is recalling certain model year 2011-2014 Chevrolet Express compressed natural gas (CNG)vehicles manufactured September 10, 2010, to April 28, 2014, and GMC Savana CNG vehicles manufactured May 23, 2011, to April 21, 2014. The affected vehicles may leak natural gas from the CNG high pressure regulator.

A natural gas leak in the presence of an ignition source increases the risk of a fire or explosion.

GM will notify owners, and dealers will replace the high pressure regulator, free of charge. The recall began February 13, 2013. Owners may contact Chevrolet customer service at 1-800-222-1020 or GMC customer service at 1-800-462-8782. GM's number for this recall is 14321.

General Motors LLC (GM) is recalling certain model year 2009-2014 Chevrolet Express and GMC Savana vans manufactured January 27, 2009, through March 7, 2014 with a gross vehicle weight rating of 10,000 pounds and less and equipped with front passenger air bags. In the affected vehicles, during a frontal impact below the air bag deployment threshold, if an unbelted front passenger's head hits the instrument panel above where the passenger air bag is located, the panel may not sufficiently absorb the impact. As such, these vehicles fail to meet the requirements of Federal Motor Vehicle Safety Standard number 201, "Occupant Protection in Interior Impact."

In the event of a crash below the air bag deployment threshold, an unbelted front passenger seat occupant has an increased risk of injury.

GM will notify owners, and dealers will modify the passenger instrument panel free of charge. Notices to the owners of the heavy duty vans were mailed on April 28, 2014. The recall began on May 19, 2014. Chevrolet owners may call 1-800-630-2438. GMC owners may call 1-866-996-9463. GM's number for this recall is 14082.