2018 Alfa Romeo Stelvio

The Stelvio, built on the same Giorgio platform as the Giulia, suffers from the same electrical gremlins. Random warning lights for the engine, transmission, ABS, and parking sensors illuminate without any actual fault present. The vehicle may enter limp mode or display a 'Service Electronic Throttle Control' message. The issues often occur intermittently and resolve after a restart.

FCA/Stellantis has released cumulative software updates for the body control module, engine control module, and transmission control module. A complete module network re-flash at the dealer using the latest wiTECH calibration files typically resolves most phantom warnings. TSB 08-085-18 REV.B covers updated diagnostic procedures.

The Uconnect infotainment system displays a black screen during startup or mid-drive, and Apple CarPlay/Android Auto connections drop frequently. The navigation system may display an incorrect vehicle position, and voice commands fail to recognize input. The Bluetooth connection to phones becomes unpaired randomly, requiring manual reconnection.

Perform a hard reset of the Uconnect system. If the issue persists, a dealer software reflash using the latest Uconnect firmware is required. If the infotainment module's internal flash storage has degraded, the module must be replaced. USB cable quality can also affect CarPlay stability — use Apple-certified cables.

Some Stelvio models with the 2.0L turbo four-cylinder exhibit oil consumption above normal levels, requiring owners to add oil between service intervals. The consumption is attributed to the turbo shaft seal or piston ring seating under high boost conditions. Owners may notice blue-gray exhaust smoke on startup or during hard acceleration.

FCA dealers can perform an oil consumption test to determine if the rate exceeds the manufacturer's threshold. If excessive, the turbocharger shaft seal should be inspected for leaks. In severe cases, the piston rings may need replacement. Using the manufacturer-specified 0W-40 oil and avoiding extended oil change intervals can help manage consumption.

The Q4 all-wheel-drive system's transfer case develops a clunking or grinding noise during tight turns or when transitioning between 2WD and AWD modes. The transfer case clutch pack can engage harshly, transmitting a shudder through the driveline. The issue is more prominent in cold weather and during low-speed maneuvering in parking structures.

A transfer case control module software update improves clutch engagement calibration. If the transfer case fluid is contaminated or low, a drain and refill with the correct specification may resolve the noise. In advanced cases, the transfer case clutch pack or the complete unit may need replacement.

The front and rear parking sensors trigger false proximity warnings when no obstacle is present. The rear camera intermittently shows a distorted image or displays a 'Camera Unavailable' message. In some cases, the parking sensors emit a continuous tone that does not stop even after the vehicle is moving. The issues are traced to sensor calibration drift and wiring harness connector corrosion.

Recalibrate the parking sensor system using the dealer diagnostic tool. Replace individual sensors that have failed or that show corrosion on the connector pins. If the rear camera module has failed, it must be replaced and recalibrated. Applying dielectric grease to sensor connectors can prevent future corrosion-related failures.

Chrysler (FCA US, LLC) is recalling certain 2017-2019 Alfa Romeo Giulia and 2018-2019 Alfa Romeo Stelvio vehicles. The fuel pump may fail, which can result in a loss of fuel flow and loss of drive power.

A loss of drive power increases the risk of a crash.

Dealers will replace the fuel delivery module, free of charge. Interim notification letters, notifying owners of the safety risk, were mailed October 7, 2025. Additional letters will be sent once the final remedy is available. Owners may contact FCA customer service at 1-800-853-1403. FCA's number for this recall is 93C. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning September 16, 2025. The information in your report suggests that Chrysler (FCA US, LLC) may have been aware of this issue more than five business days before filing a report with NHTSA. Please be reminded that under Federal law, this agency is to be notified of all safety defect and/or noncompliance decisions within five business days. 49 CFR 573.6 Significant civil penalties can be assessed for this violation.

Chrysler (FCA US, LLC) is recalling certain 2017-2024 Alfa Romeo Giulia, 2018-2025 Alfa Romeo Stelvio, 2019-2023 Fiat 500X, Jeep Renegade, and 2024 Fiat 500E vehicles. A seat belt buckle switch sensor may be improperly connected, preventing the front seat air bag from deploying as intended.

A front seat air bag that does not deploy as intended can increase the risk of injury in a crash.

Dealers will repair the connection, free of charge. Owner notification letters were mailed beginning August 27, 2024. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 82B.

Chrysler (FCA US, LLC) is recalling certain 2017-2020 Alfa Romeo Giulia and 2018-2020 Alfa Romeo Stelvio vehicles equipped with carbon ceramic matrix brakes. During certain driving maneuvers, the brake system may exert an excessive clamp force that may fracture the rotor, decreasing the brake performance.

An unexpected decrease in brake performance increases the risk of a crash.

Dealers will update the brake system module (BSM) software, free of charge. Owner notification letters were mailed July 20, 2023. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 68A.

Alfa Romeo (FCA US LLC) is recalling certain 2018-2019 Giulia and Stelvio vehicles. The Body Control Module (BCM) may indicate an inaccurate fuel level that displays higher than the actual amount.

The vehicle may be operated without enough fuel in the tank causing a stall, increasing the risk of a crash.

Alfa Romeo will notify owners, and dealers will update the BCM software, free of charge. The recall began August 12, 2019. Owners may contact Alfa Romeo customer service at 1-800-853-1403. Alfa Romeo's number for this recall is V84.

FCA US LLC (Alfa Romeo) is recalling certain 2018-2019 Alfa Romeo Stelvio and 2017-2019 Giulia vehicles. The Brake System Module (BSM) software may prevent the driver from disabling the Adaptive Cruise Control (ACC) after the traction control system detects a specific wheel slip.

The driver's inability to deactivate the ACC can increase the risk of crash.

Alfa Romeo has notified owners, and dealers will update the BSM software, free of charge. The recall began March 25, 2019. Owners may contact Alfa Romeo customer service 1-800-853-1403. The Alfa Romeo number for this recall is V27.

Chrysler (FCA US LLC) is recalling certain 2018-2019 Alfa Romeo Stelvio Quadrifoglio vehicles. The engine cooling hose may have inadequate webbing material allowing a coolant leak.

A loss of coolant can cause the engine to overheat and the vehicle to stall, increasing the risk of a crash.

Chrysler will notify owners, and dealers will replace the coolant hose, free of charge. The recall began October 10, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is U99.

Chrysler (FCA US LLC) is recalling certain 2017-2018 Alfa Romeo Giulia and 2018 Alfa Romeo Stelvio vehicles, equipped with 2.0L engines. These engines may misfire causing the catalytic converter to overheat, possibly resulting in damage to the nearby wiring and engine components.

Heat damage to the engine compartment wiring or components can increase the risk of a fire or it can cause an engine stall, increasing the risk of a crash.

Chrysler will notify owners, and dealers will inspect the vehicles for diagnostic codes, and update the engine control module software, free of charge. The recall began October 10, 2018. Owners may contact Chrysler customer service at 1-844-253-2872. Chrysler's number for this recall is UA4.

Chrysler (FCA US LLC) is recalling certain 2018 Alfa Romeo Stelvio vehicles. Water may leak into the body control module and its connectors, causing corrosion. This corrosion can cause illumination of one or more malfunction indicator lamps, a loss of windshield wiper function, a loss of exterior lighting, a loss of horn function and/or unintended turn signal activation.

Electrical malfunctions such as windshield wipers that may not work in the rain and lights that may not work at night increase the risk of a crash.

Chrysler will notify owners, and dealers will install additional sealing protection to prevent water from entering the body control module and its connectors. The recall began on April 25, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is U36.

Chrysler (FCA US LLC) is recalling certain 2018 Alfa Romeo Stelvio vehicles. Water may Leak into the wiring connectors for the rear liftgate and the liftgate-opening switch, causing corrosion.

Corrosion at the connectors may cause the liftgate to unintentionally open while moving at speeds of less than 3 miles per hour, allowing cargo to fall out of the vehicle, creating a road hazard and increasing the risk of a crash.

Chrysler will notify owners, and dealers will install additional protection against water leaking into the liftgate wiring connectors and switch, free of charge. The recall began April 25, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is U34.

Chrysler (FCA US LLC) is recalling certain 2018 Alfa Romeo Stelvio vehicles. The software for the wiper motor may incorrectly interpret the wiper motor as overheating, limiting the windshield wipers to operating only at the low-speed setting. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 104, "Windshield Wiping and Washing Systems."

Limited wiper function can reduce the driver's visibility, increasing the risk of a crash.

Chrysler will notify owners, and dealers will replace the wiper motor, free of charge. The recall began on April 25, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is U24.

Chrysler (FCA US LLC) is recalling certain 2018 Alfa Romeo Giulia and Stelvio vehicles. The braking system on these vehicles may have been filled with contaminated brake fluid, possibly damaging the system and affecting its performance.

A reduction in braking performance can increase the risk of a crash.

Alfa Romeo will notify owners, and dealers will inspect the braking system, replacing it as necessary, free of charge. The recall began February 1, 2018. Owners may contact Alfa Romeo customer service at 1-844-253-2872. Chrysler's number for this recall is T84.