2020 Ford Escape

Multiple 2022 Escape owners report the 1.5L or 2.0L EcoBoost engine burning oil at an abnormally high rate, sometimes requiring a quart added every 1,500-2,000 miles. No visible external leaks are present and the check engine light may not illuminate until levels are critically low.

Have the dealer perform a formal oil consumption test. If consumption exceeds Ford's threshold, piston ring or engine short-block replacement may be warranted under the powertrain warranty. Monitor oil level weekly between changes and use the factory-specified 0W-20 oil.

Owners report front brake pads and rotors wearing out as early as 15,000-20,000 miles. Symptoms include brake pedal pulsation, squealing, and vibration during braking. The issue is the top complaint category for the 2022 Escape on NHTSA.

Replace front brake pads and rotors. Consider upgrading to ceramic pads for longer life. Have the brake calipers inspected for proper slide pin lubrication and check for caliper drag. Avoid riding the brakes on long descents.

Some 2020-2022 Escape and Corsair vehicles exhibit a hard, stiff, or difficult-to-turn steering condition due to loss of electric power steering assist during engine startup. The steering may feel locked and requires significant force to turn.

Ford issued a TSB addressing the power steering control module. The dealer will reprogram or replace the steering assist module. If the condition occurs while driving, pull over safely and restart the engine to restore assist.

Some 2020-2022 Escape vehicles may have a fuel injector that can crack, causing a fuel leak in the engine compartment near ignition sources. This presents a fire risk and was the subject of a significant recall.

Ford issued recall 22S73 to inspect and replace the affected fuel injectors. Contact your dealer to check your VIN. The repair is free of charge. If you smell fuel or see fuel leaking, do not drive the vehicle.

Owners report the 12V battery draining overnight, SYNC infotainment freezing or going black, and various warning lights illuminating without cause. Some vehicles experience complete electrical shutdown while driving, disabling power steering and braking assistance.

Have the dealer perform a parasitic draw test and update all module firmware. Replace the 12V battery with a higher CCA-rated AGM unit if it tests weak. Ford has released software updates for modules that fail to enter sleep mode properly.

Ford Motor Company (Ford) is recalling certain 2020-2022 Escape and 2025 Escape vehicles. The liftgate hinge covers may not be properly secured and detach from the vehicle.

A detached liftgate hinge cover can create a distraction or a road hazard, increasing the risk of a crash.

Dealers will inspect and reinstall, or replace any missing liftgate hinge covers as necessary, free of charge. Interim letters, notifying owners of the safety risk were mailed January 19, 2026. Additional letters will be sent once the final remedy is available. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25SD6. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on December 3, 2025.

Ford Motor Company (Ford) is recalling certain 2016-2019 Lincoln MKC, 2016-2023 Explorer, 2019-2020 Fusion, 2019-2024 Ranger, 2020-2022 Lincoln Corsair, Escape, 2021-2024 Bronco, Bronco Sport, and 2022-2024 Maverick vehicles. The engine block heater may crack and develop a coolant leak, causing it to short circuit when the block heater is plugged in.

An electrical short circuit can increase the risk of a fire.

Owners are advised not to plug in their block heater until the vehicle is remedied. Dealers will replace the block heater, free of charge. Interim letters, notifying owners of the safety risk, were mailed December 3, 2025. Additional letters will be sent once the final remedy is available, anticipated February 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25SA4. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on October 15, 2025.

Ford Motor Company (Ford) is recalling certain 2020 Escape vehicles. The rear brake pads may have been manufactured incorrectly, which can reduce brake function in the event of a brake booster malfunction. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 135, "Light Vehicle Brake Systems."

Reduced brake function can require the driver to apply more brake pedal force, and the distance required to stop the vehicle may be extended, increasing the risk of a crash.

Dealers will replace the front brake pads, free of charge. Owner notification letters were mailed on November 5, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21C31. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on October 13, 2025. This recall is an expansion of NHTSA recall number 21V922.

Ford Motor Company (Ford) is recalling certain 2021-2024 Bronco Sport and 2020-2022 Escape vehicles equipped with 1.5L engines. A fuel injector may crack and leak fuel inside the engine compartment.

A fuel leak in the presence of an ignition source, such as hot engine or exhaust components, can increase the risk of a fire.

Dealers will update the engine control software. and replace the high pressure fuel rail assembly and the fuel injector ,free of charge. As an interim repair, dealers will update the engine control software, free of charge. Interim owner notification letters notifying owners of the safety risk were mailed August 29, 2025. Second letters will be sent once the final remedy is available, anticipated in July 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S76. This recall expands and replaces previous recall numbers 22V-859, 24V187, and 25V165. Vehicles previously remedied under 22V-859, 24V187, and 25V165 will need to have the new final remedy performed once it is available.

Ford Motor Company (Ford) is recalling certain 2018-2022 Transit Connect, 2019-2020 MKZ, MKX, Edge, Continental, F-150, Nautilus, Fusion, 2019-2023 Ranger, Mustang, 2020-2021 EcoSport, Expedition, Navigator, 2020-2022 Escape, F-250 SD, Corsair, 2020-2023 Aviator, Transit, 2020-2024 Explorer, 2021-2024 Bronco Sport, and 2022-2024 Maverick vehicles. A software error may cause the rearview camera to display a blank image, or the image may remain on the display after the backing event has ended.

A rearview camera that displays a blank image can reduce the driver's view behind the vehicle. A rearview image that continues to be displayed after the vehicle is shifted out of reverse may distract the driver. Both of these situations can increase the risk of a crash.

Dealers will update the rearview camera software, free of charge. Owner notification letters were mailed September 4, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S72.

Ford Motor Company (Ford) is recalling certain 2020-2023 Escape, 2021-2023 Corsair, and 2022-2023 Maverick vehicles equipped with 2.5L HEV or PHEV engines that were repaired incorrectly under recall 23V380. In the event of an engine failure, engine oil and fuel vapor may be released into the engine compartment and accumulate near ignition sources such as hot engine or exhaust components, possibly resulting in an engine compartment fire.

An engine compartment fire increases the risk of injury.

Owners are advised to park and shut off the engine as quickly as possible if they hear unexpected engine noises, notice a reduction in vehicle power, or see smoke. Dealers will update the powertrain control module software, free of charge. Owner notification letters were mailed June 27, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S54.

Ford Motor Company (Ford) is recalling certain 2020-2022 Escape and 2021-2023 Bronco Sport vehicles previously repaired incorrectly under recall numbers 22V-859 or 24V-187. A fuel injector may crack and leak fuel inside the engine compartment.

A fuel leak in the presence of an ignition source such as hot engine or exhaust components, can increase the risk of a fire.

Dealers will update the powertrain control module (PCM) software, free of charge. Owner notification letters were mailed April 22, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S21.

Ford Motor Company (Ford) is recalling certain 2020-2024 Ford Escape, and 2021-2024 Lincoln Corsair vehicles. A manufacturing defect in one or more of the high voltage battery cells may result in an internal short circuit and battery failure.

Battery failure can cause a loss of drive power, increasing the risk of a crash. Battery failure can also increase the risk of a fire.

Owners are advised not to charge battery till the remedy has been completed. Dealers will perform a battery energy control module (BECM) software update, and replace the high voltage battery pack, as necessary, free of charge. Owner notification letters were mailed on May 30, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S79.

Ford Motor Company (Ford) is recalling certain 2020-2025 Explorer, Lincoln Aviator, 2020-2024 Escape, Lincoln Corsair, 2018-2024 F-150, Expedition and Lincoln Navigator vehicles. The air bag warning label may be missing from the dashboard. As such, these vehicles fail to comply with the requirement Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."

Without a label that shows the proper restraint usage guidelines, the occupants may have an increased risk of injury in the event of a crash.

Ford will mail owners the warning labels, free of charge. Owner notification letters were mailed December 19, 2024. Owners may call Ford customer service at 1-866-436-7332. Ford's number for this recall is 24C39.

Ford Motor Company (Ford) is recalling certain 2022-2024 Maverick, 2020-2022 Escape, and 2021-2022 Lincoln Corsair vehicles. The Hybrid Powertrain Control Module (HPCM) software may cause the vehicle to shift into neutral unexpectedly, causing a loss of drive power.

A loss of drive power increases the risk of a crash.

Dealers will update the HPCM software, free of charge. Owner notification letters were mailed May 22, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S33.

Ford Motor Company (Ford) is recalling certain 2020-2023 Escape, 2022-2023 Maverick, and 2021-2023 Corsair vehicles equipped with 2.5L HEV or PHEV engines. In the event of an engine failure, engine oil and fuel vapor may be released into the engine compartment and accumulate near ignition sources such as hot engine or exhaust components, possibly resulting in an engine compartment fire.

An engine compartment fire increases the risk of injury.

Owners are advised to park and shut off the engine as quickly as possible if they hear unexpected engine noises, notice a reduction in vehicle power, or see smoke. Dealers will replace the engine long-block in 2023 Escape and Corsair vehicles. For the other vehicles, dealers will update the powertrain control module software. If a connecting rod bearing failure is detected, dealers will replace the engine long-block. All inspections and repairs will be performed free of charge. Owner notification letters were mailed on June 14, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S27. This recall expands and replaces recall number 22V-484. Vehicles previously repaired under 22V-484 will need to have the new remedy completed. Vehicles previously repaired under 22V-484 will need to have the new remedy completed.

Ford Motor Company (Ford) is recalling certain 2020-2023 Escape and 2021-2023 Bronco Sport vehicles equipped with 1.5L engines. A fuel injector may crack and leak fuel inside the engine compartment.

A fuel leak in the presence of an ignition source such as hot engine or exhaust components, can increase the risk of a fire.

Dealers will update the engine control software to include fuel injector leak detection and install a drain tube, free of charge. Interim owner notification letters informing owners of the safety risk were mailed January 9, 2023. Remedy parts are expected to be available in 1st Quarter of 2023. Owner notification letters were mailed February 28, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S73. This recall includes all vehicles previously recalled under 22V-191. Vehicles previously remedied under 22V-191 will need to have the new remedy performed.

Ford Motor Company (Ford) is recalling certain 2020-2022 Escape, 2021-2022 Lincoln Corsair, and 2022 Maverick vehicles equipped with 2.5L HEV or PHEV engines. In the event of an engine failure, engine oil and fuel vapor may be released into the engine compartment and accumulate near ignition sources such as hot engine or exhaust components, possibly resulting in an engine compartment fire.

An engine compartment fire increases the risk of injury.

Owners are advised to park and shut off the engine as quickly as possible if they hear unexpected engine noises, notice a reduction in vehicle power, or see smoke. Dealers will modify the under engine shield and active grille shutter, free of charge. Owner notification letters were mailed August 19, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S47.

Ford Motor Company (Ford) is recalling certain 2020 Escape and 2021 Lincoln Corsair vehicles equipped with 2.5L hybrid powertrains. Insufficient welds inside the high voltage battery may fail, resulting in a loss of drive power.

A loss of drive power increases the risk of a crash.

Dealers will replace the high voltage battery, free of charge. Interim owner notification letters notifying owners of the safety risk were mailed on July 12, 2022. Owner notification letters were mailed August 8, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S33.

Ford Motor Company (Ford) is recalling certain 2020-2022 Escape and 2021-2022 Bronco Sport vehicles equipped with 1.5L engines. The engine oil separator housing may crack and develop an oil leak.

An oil leak in the presence of an ignition source such as hot engine or exhaust components, can increase the risk of a fire.

Dealers will inspect the oil separator for damage or oil leaks, and replace the oil separator and seals, as necessary, free of charge. Owner notification letters were mailed April 18, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S21.

Ford Motor Company (Ford) is recalling certain 2020-2021 Edge, 2020 Lincoln Nautilus and Ford Escape and 2021 Lincoln Corsair and Ford Bronco Sport vehicles. An inadequate amount of lubricant in the rear drive unit may cause seizure of the rear drive axle.

If the rear drive unit seizes, there may be a loss of drive and/or a loss of vehicle control, increasing the risk of a crash.

Ford will notify owners, and dealers will check the rear drive unit lubricant level. Axles found to have lubricant at the minimum level will be filled to the full level. Axles found to be below the minimum lubricant fill level will be replaced, free of charge. This recall began March 12, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S02.

Ford Motor Company (Ford) is recalling certain 2020 Escape vehicles equipped with a key-start ignition system. The Body Control Module (BCM) intermittently may not pick up the signal from the rear Tire Pressure Monitoring System (TPMS) sensors or the Remote Key Fob. In the event of a low tire pressure condition, the TPMS system may not provide an adequate warning.

Low tire pressure may lead to poor vehicle handling and a possible loss of vehicle control, increasing the risk of crash.

Ford will notify owners, and dealers will replace the BCM, free of charge. Owners are advised that two key fobs are required for the repair to be completed. The recall began December 1, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S59.

Ford Motor Company (Ford) is recalling certain 2020 Ford F-150, F-250, F-350, F-450, F-550, Explorer, Mustang, Transit, Expedition, Escape, Ranger and Edge, and Lincoln Nautilus and Corsair vehicles. Due to a poor electrical connection, the rearview camera may intermittently display a blank or distorted image. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rear Visibility."

Reduced rearward visibility can increase the risk of a crash.

Ford will notify owners, and dealers will replace the rearview camera, free of charge. The recall began November 17, 2020. Remedy became available on February 1, 2021. Owner notification letters were mailed on February 1, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20C19.

Ford Motor Company (Ford) is recalling certain 2019-2020 Edge, Transit Connect and Lincoln MKX and 2020 Escape and Lincoln Corsair vehicles. The start/stop accumulator endcap may have missing or loose bolts.

Missing or loose bolts on the start stop accumulator endcap could result in a transmission fluid leak and may progress to a loss of transmission function. A transmission fluid leak in the presence of an ignition source may increase the risk of fire.

Ford will notify owners, and dealers will replace the start/stop accumulator, free of charge. The recall began September 23, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S49.

Ford Motor Company (Ford) is recalling certain 2020 Escape and Transit vehicles. The affected vehicles may have an improperly crimped diffuser in the side curtain air bags which may result in the diffuser detaching from the inflator in the event of an air bag deployment.

In the event of a crash, if the diffuser detaches from the inflator during air bag deployment, the curtain air bag may not inflate properly, increasing the risk of injury.

Ford will notify owners, and dealers will replace the side curtain air bag modules, free of charge. An interim letter notifying owners of the safety risk was mailed August 3, 2020. The recall began January 11, 2021. Owners may contact Ford's customer service at 1-866-436-7332. Ford's number for this recall is 20S35.

Ford Motor Company (Ford) is recalling certain 2018-2020 F-150 and 2019-2020 F-250, F-350, F-450, and F-550 Super Duty pickup trucks, and 2018-2019 Ford Explorer, 2019-2020 Expedition, and 2020 Escape vehicles equipped with driver and/or passenger's manual front seat back recliner mechanisms. Also included are certain 2020 Ford Explorer and Lincoln Aviator vehicles equipped with rear outboard seats and manual seat back recliner mechanisms. The recliner mechanisms may be missing the third pawl required for seat back strength, resulting in a loose seat back. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 202, "Head Restraints" and 207, "Seating Systems."

A seat back with an improperly assembled recliner mechanism may have reduced strength and may not adequately restrain an occupant in a crash, increasing the risk of injury.

Ford will notify owners, and Ford and Lincoln dealers will inspect the seat structure and replace them, as necessary, free of charge. The recall began October 21, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19C07.