2005 Dodge Grand Caravan
Vehicle Specs & Maintenance Data
The 2005 Dodge Grand Caravan maintenance specs on this page cover the key fluids, torque values, and wear items you need for routine service. Use these numbers as a quick reference when performing oil changes, tire rotations, brake jobs, and other scheduled maintenance on your Dodge Grand Caravan.
For oil changes, the 2005 Dodge Grand Caravan takes 5W-20 Full Synthetic motor oil with a capacity of 5 quarts. Brake fluid type is DOT 3, the recommended coolant is Mopar OAT (Purple/Violet), and transmission fluid is ATF+4. Always use the manufacturer-recommended fluids to maintain warranty coverage and engine longevity.
When mounting wheels on the Dodge Grand Caravan, torque the lug nuts to 95 ft-lbs using a calibrated torque wrench. Over- or under-torquing can lead to warped brake rotors or loose wheels. Re-torque after 50 to 100 miles on newly installed wheels.
There are 6 NHTSA safety recalls on file for the 2005 Dodge Grand Caravan. Check the Recalls tab below for full details.
Specifications on this page are compiled from multiple publicly available sources including manufacturer documentation, NHTSA data, and automotive databases. Always cross-reference with your owner's manual or official factory documentation before purchasing parts or performing any service.
The 2005 Dodge Grand Caravan uses 5W-20 Full Synthetic motor oil (5 qt capacity), requires lug nuts torqued to 95 ft-lbs, takes DOT 3 brake fluid.
Enter a diagnostic trouble code to see causes, symptoms, and fixes for the 2005 Dodge Grand Caravan.
No known problems reported for this vehicle yet.
6 NHTSA safety recalls for the 2005 Dodge Grand Caravan. Check your VIN at NHTSA.gov
EQUIPMENT ADAPTIVE/MOBILITY
ALL IN ONE MOBILITY IS RECALLING CERTAIN MODEL YEAR 1997 THROUGH 2008 CONVERSION VANS EQUIPPED WITH VMI/RICON 6-WAY POWER SEAT BASES. THERE IS A POSSIBILITY OF A DEFECTIVE WELD AT THE JOINT BETWEEN THE PIVOTING PLATE AND THE PIVOTING PLATE PIN.
THE SEAT OCCUPANT MAY BE INJURED IF THE SEAT BASE PIN WERE TO BREAK.
ALL IN ONE MOBILITY WILL NOTIFY OWNERS AND THE VEHICLES WILL BE REPAIRED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JUNE 22, 2010. OWNERS MAY CONTACT ALL IN ONE MOBILITY AT 1-503-255-5005.
SEATS
ARIZONA MOBILITY PRODUCTS (AMP) IS RECALLING ONE 2005 AND ONE 2007 CONVERSION VANS BUILT ON DODGE GRAND CARAVAN CHASSIS EQUIPPED WITH VMI/RICON 6-WAY POWER SEAT BASES. THERE IS A POSSIBILITY OF A DEFECTIVE WELD AT THE JOINT BETWEEN THE PIVOTING PLATE AND THE PIVOTING PLATE PIN.
THE SEAT OCCUPANT MAY BE INJURED IF THE SEAT BASE PIN WERE TO BREAK.
AMP WILL NOTIFY OWNERS AND REPAIR VEHICLES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JUNE 10, 2010. OWNERS MAY CONTACT AMP AT 1-602-385-5988.
AIR BAGS:FRONTAL:SENSOR/CONTROL MODULE-INACTIVE
CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2005-2006 DODGE CARAVAN, GRAND CARAVAN AND CHRYSLER TOWN & COUNTRY VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, IOWA, ILLINOIS, INDIANA, KANSAS, KENTUCKY, MASSACHUSETTS, MAINE, MARYLAND, MICHIGAN, MINNESOTA, MISSOURI, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, NORTH DAKOTA, OHIO, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, TENNESSEE, UTAH, VERMONT, VIRGINIA, WEST VIRGINIA, WISCONSIN, ALASKA AND THE DISTRICT OF COLUMBIA. THE FRONT CRASH SENSORS MAY CRACK UNDER CERTAIN ENVIRONMENTAL CONDITIONS AND ALLOW WATER TO ENTER INTO THE SENSOR. THIS CAN CAUSE THE SENSOR TO BECOME INOPERATIVE AND ILLUMINATE THE AIRBAG WARNING LIGHT. THESE SENSORS WERE ADDED TO ENHANCE THE PERFORMANCE OF THE AIRBAG SYSTEM IN CERTAIN FRONTAL CRASHES.
IF THE FRONT CRASH SENSORS BECOME INOPERATIVE, THE DRIVER IS IMMEDIATELY ALERTED BY ILLUMINATION OF THE AIRBAG WARNING LIGHT AND THE VEHICLE SHOULD BE PROMPTLY SERVICED. UNTIL THE VEHICLE IS REPAIRED, THE AIRBAGS MAY NOT PROVIDE THE ENHANCED PROTECTION IN THE EVENT OF A CRASH.
CHRYSLER WILL REPLACE THE FRONT AIRBAG SENSORS WITH A NEW DESIGN. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY IMPROVEMENT CAMPAIGN WILL BEGIN DURING JUNE 2010. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
VISIBILITY:GLASS, SIDE/REAR
CERTAIN CURVED TEMPERED REPLACEMENT GLASS MANUFACTURED BY HANGZHOU SAFETY GLASS LTD AND SUPPLIED TO SAFELITE BY AUTO TEMP INC., IDENTIFIED AS DOT-430, AND SOLD FOR USE ON CERTAIN DOMESTIC AND FOREIGN VEHICLES MAY NOT BREAK INTO SMALL PIECES AS EXPECTED OF TEMPERED GLASS AND FAILS TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 205, "GLAZING MATERIALS."
IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT(S) MAY BE SERIOUSLY INJURED BY SHATTERED GLASS.
SAFELITE WILL NOTIFY ITS RETAIL CUSTOMERS AND REPLACE THE GLASS FREE OF CHARGE. RETAIL CUSTOMERS CAN CONTACT SAFELITE TOLL FREE AT 1-888-843-2906. SAFELITE WILL NOTIFY ITS WHOLESALE CUSTOMERS AND REIMBURSE WHOLESALE CUSTOMERS FOR CURRENT INVENTORY AND AT A SPECIFIED RATE FOR REPLACING THEIR CUSTOMER'S GLASS. WHOLESALE CUSTOMERS CAN CONTACT SAFELITE'S WHOLESALE DIVISION, SERVICE AUTOGLASS TOLL FREE AT 1-888-246-6298. THE RECALL BEGAN ON JANUARY 15, 2008.
VISIBILITY:WINDSHIELD WIPER/WASHER:MOTOR
ON CERTAIN VANS AND SPORT UTILITY VEHICLES, THE FRONT WINDSHIELD WIPER MOTOR ARMATURE SHAFT MAY BREAK.
DURING CERTAIN OPERATING CONDITIONS, LOSS OF FRONT WINDSHIELD WIPING CAPABILITY COULD OCCUR, AND THE DRIVER'S VISION COULD BE OBSCURED WHICH COULD RESULT IN A CRASH.
DEALERS WILL INSPECT AND REPLACE THE WINDSHIELD WIPER MOTOR FREE OF CHARGE. THE RECALL BEGAN ON JUNE 19, 2006, TO DODGE DURANGO OWNERS. MINIVAN OWNERS WILL BE NOTIFIED DURING JULY 2006. OWNERS MAY CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
SEAT BELTS:FRONT:RETRACTOR
AFTER PERFORMING THE NCAP TEST, IT WAS DISCOVERED THAT ON CERTAIN MINIVANS EQUIPPED WITHOUT THE AVAILABLE "STOW 'N GO" SEATING OPTION, THE RIGHT FRONT SEAT BELT RETRACTOR ASSEMBLY MAY HAVE BEEN IMPROPERLY ASSEMBLED.
AS A RESULT, THE SEAT BELT MAY NOT PROPERLY RESTRAIN THE OCCUPANT DURING CERTAIN CRASH CONDITIONS, WHICH CAN INCREASE THE RISK OF INJURY.
DEALERS WILL INSPECT THE RETRACTOR ASSEMBLIES AND ANY SEAT BELT ASSEMBLY THAT DOES NOT HAVE THE STAKE WILL BE REPLACED. OWNER NOTIFICATION BEGAN ON FEBRUARY 23, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.