2018 Alfa Romeo Giulia

The Giulia is plagued by electrical issues including random dashboard warning lights, intermittent limp mode activation, and unexplained faults in the body control module. Owners report the check engine light, traction control warning, and tire pressure monitoring light all illuminating simultaneously without any underlying mechanical fault. The issues often clear after restarting the vehicle.

A dealer software update to the body control module and engine control module resolves many phantom warning lights. Wiring harness connections should be inspected for loose pins or corrosion. FCA/Stellantis has released multiple calibration updates to address electrical communication faults. TSB 08-085-18 REV.A covers electrical fault diagnosis.

The Uconnect 8.8-inch infotainment system freezes, goes to a black screen, or enters a reboot loop while driving. Navigation stops providing directions, phone calls are disconnected, and the backup camera becomes unavailable. The system's built-in storage can become corrupted, requiring a complete reinstallation.

Perform a hard reset of the Uconnect system by holding the volume and tune knobs simultaneously for 10-15 seconds. If the issue persists, a dealer software reflash or replacement of the infotainment module is needed. FCA/Stellantis TSB 08-065-18 addresses Uconnect system stability improvements.

Some Giulia models with the 2.0L turbo four-cylinder experience intermittent engine stalling at idle or when coming to a stop. The engine drops RPM sharply and may stall without warning, leaving the driver without power steering or brake assist momentarily. The issue has been linked to a fuel pump control module software fault and an electronic throttle body calibration error.

A powertrain control module (PCM) software update addressing idle stability and fuel pump control is the primary fix. FCA recall W19/Alfa Romeo recall 19V-660 addresses stalling concerns on certain Giulia and Stelvio models. The electronic throttle body should be cleaned and recalibrated during the service.

The rear power window regulators fail prematurely, causing the window to fall into the door panel or become stuck in the up or down position. Additionally, the exterior door handles — which use a flush, electronic-release design — can fail to actuate the latch, leaving occupants unable to open the door from the outside.

Replace the rear window regulator assembly. The door handle electronic release mechanism must be replaced if it has failed, which requires removing the interior door panel and outer trim. FCA has released updated door handle actuators with improved durability for the Giulia platform.

The ZF 8HP 8-speed automatic transmission can exhibit harsh downshifts, delayed engagement from park to drive, and a noticeable clunk when shifting at low speed. In Dynamic mode, the transmission holds gears aggressively and delivers jarring downshifts. Some owners report a shudder during gentle acceleration in higher gears.

A transmission control module (TCM) software update improves shift quality and adaptive learning. A transmission fluid service with the correct ZF LifeGuard 8 fluid can resolve shudder issues. If the torque converter develops a shudder, it may need replacement. FCA TSB 21-011-18 covers shift quality improvements.

Chrysler (FCA US, LLC) is recalling certain 2017-2019 Alfa Romeo Giulia and 2018-2019 Alfa Romeo Stelvio vehicles. The fuel pump may fail, which can result in a loss of fuel flow and loss of drive power.

A loss of drive power increases the risk of a crash.

Dealers will replace the fuel delivery module, free of charge. Interim notification letters, notifying owners of the safety risk, were mailed October 7, 2025. Additional letters will be sent once the final remedy is available. Owners may contact FCA customer service at 1-800-853-1403. FCA's number for this recall is 93C. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning September 16, 2025. The information in your report suggests that Chrysler (FCA US, LLC) may have been aware of this issue more than five business days before filing a report with NHTSA. Please be reminded that under Federal law, this agency is to be notified of all safety defect and/or noncompliance decisions within five business days. 49 CFR 573.6 Significant civil penalties can be assessed for this violation.

Chrysler (FCA US, LLC) is recalling certain 2017-2024 Alfa Romeo Giulia and 2021-2024 Alfa Romeo Stelvio vehicles. The tire pressure and size information on the tire placard and manufacturer labels are incorrect. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 110, "Tire Selection and Rims."

Incorrect tire information can result in under-inflated tires or installing the incorrect-size tires, increasing the risk of a crash.

FCA will mail corrected tire placards and manufacturer overlay labels. Owners may bring the labels into a dealer for free installation. Some interim notification letters, notifying owners of the safety risk, were mailed August 27, 2024. Owner notification letters were mailed August 5, 2024 through November 1, 2024. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 81B.

Chrysler (FCA US, LLC) is recalling certain 2017-2024 Alfa Romeo Giulia, 2018-2025 Alfa Romeo Stelvio, 2019-2023 Fiat 500X, Jeep Renegade, and 2024 Fiat 500E vehicles. A seat belt buckle switch sensor may be improperly connected, preventing the front seat air bag from deploying as intended.

A front seat air bag that does not deploy as intended can increase the risk of injury in a crash.

Dealers will repair the connection, free of charge. Owner notification letters were mailed beginning August 27, 2024. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 82B.

Chrysler (FCA US, LLC) is recalling certain 2017-2020 Alfa Romeo Giulia and 2018-2020 Alfa Romeo Stelvio vehicles equipped with carbon ceramic matrix brakes. During certain driving maneuvers, the brake system may exert an excessive clamp force that may fracture the rotor, decreasing the brake performance.

An unexpected decrease in brake performance increases the risk of a crash.

Dealers will update the brake system module (BSM) software, free of charge. Owner notification letters were mailed July 20, 2023. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 68A.

Alfa Romeo (FCA US LLC) is recalling certain 2018-2019 Giulia and Stelvio vehicles. The Body Control Module (BCM) may indicate an inaccurate fuel level that displays higher than the actual amount.

The vehicle may be operated without enough fuel in the tank causing a stall, increasing the risk of a crash.

Alfa Romeo will notify owners, and dealers will update the BCM software, free of charge. The recall began August 12, 2019. Owners may contact Alfa Romeo customer service at 1-800-853-1403. Alfa Romeo's number for this recall is V84.

FCA US LLC (Alfa Romeo) is recalling certain 2018-2019 Alfa Romeo Stelvio and 2017-2019 Giulia vehicles. The Brake System Module (BSM) software may prevent the driver from disabling the Adaptive Cruise Control (ACC) after the traction control system detects a specific wheel slip.

The driver's inability to deactivate the ACC can increase the risk of crash.

Alfa Romeo has notified owners, and dealers will update the BSM software, free of charge. The recall began March 25, 2019. Owners may contact Alfa Romeo customer service 1-800-853-1403. The Alfa Romeo number for this recall is V27.

Chrysler (FCA US LLC) is recalling certain 2017-2018 Alfa Romeo Giulia vehicles equipped with GME 280HP engines and All Wheel Drive ("AWD"). The brake fluid line may contact a coolant hose clamp, possibly causing brake fluid to leak onto the exhaust.

Brake fluid leaking onto the exhaust can increase the risk of a fire.

Chrysler will notify owners, and dealers will install a bracket on the brake fluid line to prevent contact with the coolant hose clamp. If damage is found on the brake line, it will be replaced, free of charge. The recall began January 10, 2019. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is UB9.

Chrysler (FCA US LLC) is recalling certain 2017-2018 Alfa Romeo Giulia and 2018 Alfa Romeo Stelvio vehicles, equipped with 2.0L engines. These engines may misfire causing the catalytic converter to overheat, possibly resulting in damage to the nearby wiring and engine components.

Heat damage to the engine compartment wiring or components can increase the risk of a fire or it can cause an engine stall, increasing the risk of a crash.

Chrysler will notify owners, and dealers will inspect the vehicles for diagnostic codes, and update the engine control module software, free of charge. The recall began October 10, 2018. Owners may contact Chrysler customer service at 1-844-253-2872. Chrysler's number for this recall is UA4.

Chrysler (FCA US LLC) is recalling certain 2018 Alfa Romeo Giulia and Stelvio vehicles. The braking system on these vehicles may have been filled with contaminated brake fluid, possibly damaging the system and affecting its performance.

A reduction in braking performance can increase the risk of a crash.

Alfa Romeo will notify owners, and dealers will inspect the braking system, replacing it as necessary, free of charge. The recall began February 1, 2018. Owners may contact Alfa Romeo customer service at 1-844-253-2872. Chrysler's number for this recall is T84.